Page 1 of 1

Samsung DLP TV burnt out 3 lamps in 3 months!?!?!

Posted: Sat Apr 09, 2011 4:27 pm
by smc4434
My Samsung DLP TV has burnt out 3 lamps in 3 months. I got an original replacement lamp all 3 times from samsungparts.com. Every time I install a new lamp it works fine for about a month and then the lamp blows again. I have opened the tv up and cleaned out all of the dust and made sure the fans were working properly. Could there be something else causing these bulbs to go bad???

Re: Samsung DLP TV burnt out 3 lamps in 3 months!?!?!

Posted: Tue Apr 12, 2011 5:13 pm
by grayfox
Hello,
wow this sounds expensive! :shock: The ballast is what generates power to the lamp ;) , I am assuming there is a malfunction with this part... :geek:
were all three lamps physically burnt when removed? :?:

Samsung DLP TV burnt out 3 lamps in 3 months

Posted: Thu Jun 16, 2011 6:07 pm
by grodayarera
I have a Sony VPD-MX10 and the lamp burnt out. I bought a replacement lamp from Advanced Lamps and within 3 weeks the replacement burn out.

Any ideas why this would happen so quickly?

Re: Samsung DLP TV burnt out 3 lamps in 3 months!?!?!

Posted: Thu Jun 16, 2011 10:35 pm
by grayfox
Hello,
It is really rare that this would happen, is the lamp physically damaged/defective??? or is it not an OEM brand lamp (Philips, Osram, etc) because if its generic it most probably did fail...

Re: Samsung DLP TV burnt out 3 lamps in 3 months!?!?!

Posted: Thu Sep 15, 2011 3:55 am
by Samsungtech
There is a known issue with some of the DLP series burning lamps, the solution recommended by Samsung is to replace SMPS, Ballast along with the lamp.
this typically applies to all DLPs that use the BP44-01001a or BP44-01002a Power Supply.

Re: Samsung DLP TV burnt out 3 lamps in 3 months!?!?!

Posted: Thu Sep 15, 2011 4:05 pm
by grayfox
hello samsungtech,

by "SMPS" et all, you mean this problem can only be fixed completely by changing the power supply, ballast and the lamp??? thank you!

Re: Samsung DLP TV burnt out 3 lamps in 3 months!?!?!

Posted: Fri Sep 16, 2011 1:55 am
by Samsungtech
Sorry SMPS just means switch mode power supply which is what most of Samsung TVs use. The power supply PCB is what I was referring to.

Re: Samsung DLP TV burnt out 3 lamps in 3 months!?!?!

Posted: Fri Sep 16, 2011 6:01 pm
by grayfox
yup that was noted, I was asking if you meant changing all three at the same time ! that sucks